Characterisation of Novel Nitrogen Doped Reduced Graphene Oxide

Abstract

The utilisation of fuel cells in everyday life is of critical importance for the introduction of clean energy and departure from carbon-based economy. The oxygen reduction reaction (ORR) rate on the cathode is the key factor for effective polymer electrolyte membrane fuel cells. Therefore, novel cathode catalysts have to be designed to reduce the ORR over voltage. One of the most efficient ways to increase the ORR rate is to use nitrogen doping of carbon materials.1 Such materials are also promising for applications in supercapacitors and other energy storage devices.2 In this work, experimental results based on a nitrogen-doped reduced graphene oxide are presented. The nitrogen-doped reduced graphene oxide has been produced by Sea Further SARL using a biological micro-organisms and non-toxic chemicals.3 The material has been characterised by several physical methods: particle size distribution analysis, X-ray diffraction, X-ray photoelectron spectroscopy, thermogravimetric analysis, gas adsorption method, and electrical conductivity measurements. X-ray diffraction data reveal the presence of peaks characteristic to reduced graphene oxide. The specific surface area of the bulk material is around 2.4 m2 g− 1 based on the nitrogen adsorption method. The bulk sample, in powder form, exhibited considerable specific conductance under pressure.Additionally, electrochemical measurements have been conducted in 0.1 M HClO₄ and 0.1 M KOH solutions. The electrochemical stability, capacitive behaviour, and ORR activity of nitrogen-doped reduced graphene oxide have been determined using cyclic voltammetry, rotating disc electrode and electrochemical impedance spectroscopy methods. The material under discussion has a good electrochemical stability within the investigated potential region in both media. The measurement data show that the ORR kinetics in alkaline media is much faster than in acidic media. Surprisingly, this material has a high gravimetric capacitance. Therefore, nitrogen-doped reduced graphene oxide has high potential for energy storage devices and is promising co-catalyst material in fuel cell. Acknowledgements This work was supported by the EU through the European Regional Development Fund under project TK 141 “Advanced materials and high-technology devices for energy recuperation systems” (grant number 2014 2020.4.01.15 0011); and by the Estonian Research Council (grant number PUT PRG 676). References N. Daems, X. Sheng, I.F.J. Vankelecom, and P.P. Pescarmona, J. Mater. Chem. A, 2, 4085 (2014).N.A. Elessawy, J.E. Nady, W. Wazeer, and A.B. Kashyout, Sci. Rep., 9, 1129 (2019).V. Iakimov, International Patent Application No. WO2021/059152, WIPO, April 1st 2021.