Biological monitoring of occupational exposure to methyl ethyl ketone

Abstract

This study was conducted to evaluate the usefulness of three commonly used methods of biological monitoring for worker exposed to methyl ethyl ketone (MEK) under field conditions using blood, breath and urine. Environmental MEK exposures were measured by personal sampling with carbon-felt dosimeters. The correlation coefficient (r) between the time-weighted average (TWA) MEK concentration in air and the MEK concentration in blood collected at the end of the work shift was 0.85. The correlation coefficient between the TWA MEK level in air and the concentration exhaled in the breath of workers at the end of the work shift was 0.71. The end-of-shift urinary MEK excretion correlated best with the environmental concentration (r = 0.89). Correlations became lower after urine samples had been corrected for urinary creatinine (r = 0.83) or specific gravity (r = 0.73). After 8 h exposure to 200 ppm MEK, the corresponding end-of-shift urinary excretion was 5.1 mumol/l or 4.11 mg/g creatinine. This value is higher than that previously found in some studies, the difference probably being due to the physical activities of the present workers and their extensive skin contact with the solvent. The kinetics of inhaled MEK was also studied in eight subjects. Breath and urine samples were collected during the 8-h work shift on 2 consecutive Mondays. The results showed that urinary MEK excretion rose steadily until the end of exposure, whereas the MEK concentration in exhaled air varied markedly throughout the day.(ABSTRACT TRUNCATED AT 250 WORDS)