Applying the coagulation and reverse osmosis for water recovery from evaporative water

Abstract

Abstract Applying the coagulation and reverse osmosis for water recovery from evaporative water. Evaporative water from the concentration of yeast slurry is a potential raw material for water recovery. It is characterized by low pH (4.6-6.3), increased turbidity (3.65-13.7 NTU), and high content of total organic carbon (356-754 mg/L). Its treatment in the volume coagulation process using NaOH and coagulant PIX 111, was studied. Water turbidity was lowered to a value below 1 NTU, but coagulation did not allow for the removal of organic compounds. Coagulation was effective at temperatures of 20 and 40°C. Pretreatment of the feed water for RO included alkalization, coagulation, sedimentation, and 5 μm fine filtration (variant I), as well as single 5 μm fine filtration (variant II as a blank). In variant I the feed with improved properties was achieved. Membrane filtration allowed for effective desalination of evaporative water, 98 and 73% conductivity retention was obtained, depending on the method of the feed pre-treatment. The organic compounds were removed less efficiently, at 94 and 84%, respectively.