Abstract
Electroless nickel plating wastewaters commonly contain the citrate chelating complex and the coexisting hypophosphite, which is a scavenger of hydroxyl radicals, typically lowers the catalytic efficiency of H2O2 by Fe2+ in Fenton reaction. Hence, in this work, the Fered-Fenton method was adopted to remediate the citrate, and then alkaline precipitation was utilized to remove the freed nickel ions. The chemical oxidation demand (COD) of citric acid could be efficiently reduced by approximately 95% using 1080mM H2O2 (dosed in continual mode) and 20mM ferrous ions at a current density of 190Am−2 ([citric acid]=100mM and [Ni]=100mM). Meanwhile, 99.9% of the nickel that was liberated from the chelation of citric acid was removed by the cathodic deposition and the sequential precipitation. The hypophosphite did not significantly influence the COD or nickel removal efficiency. Finally, those optimal conditions for the successful management of simulated electroless plating wastewater consisted of citric acid and nickel ions coexisting with hypophosphite were then used to demonstrate the treatment of real wastewater (45,000ppm COD and 8000ppm nickel ions). The high COD removal, 93%, from the effluents of the electroless nickel plating process verified that the Fered-Fenton process can be practically applied.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.