Analysis of mycotoxins in barley using ultra high liquid chromatography high resolution mass spectrometry: Comparison of efficiency and efficacy of different extraction procedures

Abstract

The effectiveness of four extraction methods (modified QuEChERS, matrix solid-phase dispersion (MSPD), solid–liquid extraction (SLE) and solid-phase extraction (SPE) clean-up) were evaluated for simultaneous determination of 32 mycotoxins produced by the genus Fusarium, Claviceps, Aspergillus, Penicillium and Alternaria in barley by ultra high pressure liquid chromatography coupled to ultra-high resolution mass spectrometry (UHPLC-Orbitrap® MS). The efficiency and efficacy of extraction methods were evaluated and compared in number of extracted mycotoxins and obtained recoveries. From the one point of view, QuEChERS procedure was fast and easy, as well as it was able to successfully extract all selected mycotoxins. On the other hand, SLE method, MSPD and SPE clean-up method did not extract adequately all selected mycotoxins and recoveries were not suitable enough. Thereby, method employing QuEChERS extraction connected with UHPLC-Orbitrap® MS was developed to quantify 32 mycotoxins in barley within this study. Analytical method was validated and recoveries ranged from 72% to 101% for selected mycotoxins with only one exception nivalenol (NIV) and deoxynivalenol-3-glucoside (D3G), which were lower than 67%. Relative standard deviations (RSD) were lower than 17.4% for all target mycotoxins. The lowest calibration levels (LCLs) ranged from 1 to 100μg/kg. Validated method was finally used for monitoring mycotoxins in a total of 15 Czech barley samples, when only Fusarium toxins representatives were detected in 53% of samples and the mycotoxins with the highest incidence were enniatins.