Abstract
The mushroom agroindustry generates a huge amount of waste from mushroom production (WMP). The composition of WMP is not standardized but differs mainly in terms of organic matter (OM) content and OM biodegradability. This makes WMP management, including anaerobic digestion (AD), a significant challenge. A potential solution could be co-digestion of WMP with municipal sewage sludge (SS), especially SS generated in small rural wastewater treatment plants (WWTPs). Therefore, this study investigated mesophilic methane production (MP) from WMP, SS, and mixtures of SS and WMP at ratios of 70:30, 50:50, and 30:70 (w/w OM). Even though the maximum cumulative MP from WMP was relatively low (approx. 60 NL/kg OM), co-digesting WMP with SS increased both MP and the methane content of the biogas: with 30%, 50%, and 70% shares of SS, MP increased almost 2, 2.5, and 3.3 times, and the methane content increased to 61%, 62%, and 64%, respectively. As the SS content was increased, the kinetic coefficients of MP and OM removal decreased (from 0.211 to 0.146 d−1 and from 0.215 to 0.152 d−1), whereas the initial rate of MP and of OM removal increased (from 12.5 to 36.8 NL/(kg OM·d) and from 0.51 kg OM/(m3·d) to 0.59 kg OM/(m3·d), respectively). The effectiveness of OM removal (EOMrem) was lowest with WMP only, at 46.6%. When the SS content of the mixtures was increased to 30%, 50%, and 70%, EOMrem also increased to 55.3%, 60.1%, and 64.9%, respectively. The relationship between maximal MP and the overall OM removed was such that both increased simultaneously. The higher values of EOMrem and, consequently, the lower final contents of OM with more effective MP indicate that the organics were degraded more efficiently. These results suggest that co-digestion may be a profitable solution for simultaneously utilizing both of these waste products, increasing the efficiency of biogas production to such an extent that it would be profitable to conduct AD on mushroom farms. This is a flexible approach that allows varying proportions of WMP and SS to be used, depending on the availability of both substrates and the energy needs of the mushroom farm. However, it should be borne in mind that a higher share of WMP results in lower gas productivity.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Similar Papers
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.