Abstract
A single-element rotating-polarizer ellipsometer (psi-meter) was used for in situ characterization of the thermodynamic and kinetic behavior of poly-(methyl methacrylate), PMMA, thin films (1.2 μm) in solvent/nonsolvent binary mixtures of methyl ethyl ketone/isopropanol (MEK/IPA) and methyl isobutyl ketone/methanol (MIBK/MeOH). Thermodynamic effects were inferred from equilibrium behavior by the degree of swelling and polymer-solvent solubility. A sharp transition between complete solubility and almost total insolubility was observed in a narrow concentration range near 50:50 (by volume) solvent/nonsolvent for both MEK/IPA and MIBK/MeOH. In the insoluble regime, the polymer was found to swell up to three times the initial thickness. At 50:50 MEK/IPA, a temperature decrease from 24.8 to 18.4 °C caused a change from complete dissolution to combined swelling/dissolution behavior and rendered the PMMA film only 68% soluble. Kinetic effects were determined by dissolution and penetration rate measurements. A constant penetration velocity was observed for almost all compositions for both binary solvent mixtures with Case II transport assumptions providing good agreement with experimental results. For MEK/IPA, penetration rates increased with increasing MEK concentration. For MIBK/MeOH, however, a maximum was observed at 60:40 MIBK/MeOH.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a callDisclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.
