A rapid HPLC method for determination of Sudan dyes and Para Red in red chilli pepper

Abstract

A rapid high-performance liquid chromatography (HPLC) system consisting of an ultraviolet-visible (UV–VIS) detector was developed for the separation and determination of Sudan dyes (I, II, III, and IV) and Para Red in red chilli peppers. The chromatographic separation was achieved on a reverse phase C 18 column with isocratic elution, using a mobile phase of acetonitrile/methanol (80:20, v/v); detector was set at 506 nm. All four Sudan dyes and Para Red were separated in less than 9 min. Among 80 red chilli peppers screened, only one of them contained 0.10, 0.04, and 0.05 mg/kg Sudans I, III, and IV, respectively. No Sudan II and Para Red were detected in any of the red chilli peppers analysed. The method was ‘in-house’ validated using red chilli peppers based on following criteria: limit of detection (LOD), limit of quantification (LOQ), recovery, repeatability, reproducibility, and linearity in red chilli peppers. Depending on the dye involved, LOD and LOQ were in the range of 1.2–5.4 and 4–18 μg/kg in red chilli, respectively. The recovery, repeatability (expressed as coefficient of variation, CV r), and reproducibility (CV R) varied from 89 to 98%, from 0.82 to 4.09%, and from 1.33 to 4.65%, respectively. Linearity obtained for all dyes and Para Red were all r 2 > 0.9999 (in the range of 0.01–5 mg/l). The applicability of the method to the determination of Sudan dyes and Para Red in red chilli peppers was demonstrated. This method has potential to be used for illegal Sudan dyes and Para Red in red chilli peppers and some foodstuffs due to its simple, reliable, rapid, and excellent precision.