A novel LC-QTOF-MS/MS method for trace level identification and quantification of potential genotoxic impurity, 5-Nitro-2-(propylthio)pyrimidine-4,6-diol in ticagrelor drug substance

Abstract

An important objective of the present work is to develop and validate a novel LC-QTOF-MS/MS method to identify and quantify 5-Nitro-2-(propylthio) pyrimidine-4,6-diol genotoxic impurity at trace level (∼8.33 ppm) in ticagrelor drug substance, is an antiplatelet medicine used in the treatment of heart attacks and strokes. The potential genotoxic impurities must be controlled below acceptance limit during process of ticagrelor synthesis and release. In reversed-phase mode, the ACQUITY UPLC CSH C18 (2.1 mm x 100 mm, 1.7 μm) with ambient column temperature was used. 0.1% formic acid in Milli-Q water and methanol in the ratio of 30:70 v/v used as mobile phase A and mobile phase B with isocratic elution mode and the run time was 8.0 min. The flow rate was maintained at 0.25 mL/min, autosampler temperature was 5°C, Injection volume was 20 μL. The Retention time of 5-Nitro-2-(propylthio)pyrimidine-4,6-diol was found at 1.345 minutes. Limit of detection (LOD) and limit of quantification (LOQ) were found at 0.56 ppm and 1.67 ppm, respectively. The 5-Nitro-2-(propylthio)pyrimidine-4,6-diol was linear (R2=0.9986) over the concentration range 1.666 to 12.495 ppm. The method was accurate and precise, it was demonstrated by calculating the %mean recovery values ranging from 98.0-106.9%.