Abstract
SummaryThree different process types of heat supply for industrial production processes requiring low temperature heat at 140°C are analyzed and compared with each other. The thermodynamic and economic efficiency of a gas turbine process with a heat recovery boiler (GT), a gas and steam turbine combined cycle process with a back-pressure turbine (GT-CC) and a high temperature heat pump (HTHP) system recovering waste heat from humid exhaust air between 90°C and 50°C are assessed based on energy flows, exergy flows and costs of heat provided as 4 bar (abs) saturated steam. The economic analysis bases on the comparison of the consumption-related costs of heat, the capital-related costs of heat and the operation-related costs of heat. The payback-times are calculated for different HTHP investment cost levels (1000 EUR/kWQ, 750 EUR/kWQ, 500 EUR/kWQand 250 EUR/kWQ). To evaluate the effects of fluctuating energy costs, a sensitivity analysis with varying gas and electricity prices has been carried out.The results show that the HTHP system, even with modest performance assumptions, has a higher exergetic efficiency than the GT or the GT-CC process. For the consumption-related costs, the economic calculation shows that the operation of a HTHP, working with a coefficient of performance (COP) of four and for a natural gas price of 25 EUR/MWh, is the cheapest way of heat production as long as the electricity price is lower than 45 EUR/MWh. An electricity price above 45 EUR/MWh makes a GT-CC process more favorable. For the period from January 2013 until June 2016, the total costs of heat and the payback times, based on real gas and electricity prices from the EEX, are calculated and analyzed. For overall cost-optimized heat supply, the results show that the share of heat provided by the HTHP system varies between 45% and 76% between January 2013 and June 2016. Especially in 2013 and 2014, the economic conditions for operating heat pumps were very good. Since October 2015, the natural gas prices have seen a decrease and the economic conditions shifted again favoring the industrial heat supply with combined heat and power systems.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a callMore From: Die Bodenkultur: Journal of Land Management, Food and Environment
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.
