Paclitaxel-loaded Lipid Nanocapsules Research Articles

Mechanism of cellular uptake and cytotoxicity of paclitaxel loaded lipid nanocapsules in breast cancer cells

Lipid nanocapsules (LNCs) have proven their efficacy in delivering different drugs to various cancers, but no studies have yet described their uptake mechanisms, paclitaxel (PTX) delivery or resulting cytotoxicity towards breast cancer cells. Herein, we report results concerning cellular uptake of LNCs and cytotoxicity studies of PTX-loaded LNCs (LNCs-PTX) on the three breast cancer cell lines MCF-7, MDA-MB-231 and MDA-MB-468. LNCs-PTX of sizes 50 ± 2 nm, 90 ± 3 nm and 120 ± 4 nm were developed by the phase inversion method. Fluorescence microscopy and flow cytometry were used to observe the uptake of fluorescently labeled LNCs and cellular uptake of LNCs-PTX was measured using HPLC analyses of cell samples. These studies revealed a higher uptake of LNCs-PTX in MDA-MB-468 cells than in the other two cell lines. Moreover, free PTX and LNCs-PTX exhibited a similar pattern of toxicity towards each cell line, but MDA-MB-468 cells appeared to be more sensitive than the other two cell lines, as evaluated by the MTT cytotoxicity assay and a cell proliferation assay based upon [3H]thymidine incorporation. Studies with inhibitors of endocytosis indicate that the cellular uptake is mainly via the Cdc42/GRAF-dependent endocytosis as well as by macropinocytosis, whereas dynamin-dependent processes are not required. Furthermore, our results indicate that endocytosis of LNCs-PTX is important for the toxic effect on cells. Western blot analysis revealed that LNCs-PTX induce cytotoxicity by means of apoptosis in all the three cell lines. Altogether, the results demonstrate that LNCs-PTX exploit different mechanisms of endocytosis in a cell-type dependent manner, and subsequently induce apoptotic cell death in the breast cancer cells here studied. The article also describes biodistribution studies following intravenous injection of fluorescently labeled LNCs in mice.

Absence of lung fibrosis after a single pulmonary delivery of lipid nanocapsules in rats.

Lipid nanocapsules (LNCs) are potential drug carriers for pulmonary delivery since they can be nebulized without any structural or functional changes, and the aerosols produced are highly compatible with pulmonary drug delivery in human beings. The alveolar surface tension, in vitro cytotoxicity, biodistribution and pulmonary toxicity in rats of a single endotracheal spray of LNCs or paclitaxel-loaded LNCs were studied. In vitro cytotoxicity of LNCs after a spray remained unchanged. Biodistribution study showed a homogeneous repartition in the lungs in rats with an improvement in lung retention of the radiolabeled tracer loaded in LNCs compared to the absence of LNCs with a lung half-time of 8.8±0.7 hours. Bronchoalveolar fluid analysis revealed transient 7-day alveolar inflammation, reaching a maximum between days 2 and 4, characterized by a peak of granulocytes at day 1 followed by a peak of lymphocytes at day 3. Alveolar protein levels were increased at days 3 and 7. Acute inflammation was increased with paclitaxel-loaded LNCs in comparison with blank LNCs but dropped out at day 7. No histological pulmonary lesion was observed at day 60. LNCs lowered surface tension to a greater degree than Curosurf® in a physicochemical model of the pulmonary alveolus. A single pulmonary delivery of LNCs induces a short-term alveolar inflammation with no residual lesions in rats at day 60. These data permit to start the study of LNCs in surfactant replacement therapy.

Development of nanoparticles for clinical use.

During recent years, there has been much interest in using nanoparticles (NPs) for delivery of therapeutic drugs or contrast agents. Many interesting in vitro and animal studies have been reported [1–3], and some NP-based products are already in clinical use. Iron-oxide containing NPs have been used as iron supplement or contrast agents in MRI for more than 20 years [4,5]. Albumin and liposomal-based products containing anticancer drugs have also been available for several years, and new NP-based products are in clinical trials [2,6]. The discrepancy between the large number of papers published about NPs and other drug candidates versus the few new drugs entering the market is heavily debated, and important discussions regarding what is needed to bring new products to the market have been published [6–9]. No doubt, there are many challenges to overcome before NPs may become common tools in clinical practice.

Development of 2D and 3D Mucus Models and Their Interactions with Mucus-Penetrating Paclitaxel-Loaded Lipid Nanocapsules

To study, diffusion through mucus (3D model) of different formulations of paclitaxel loaded lipid nanocapsules (Ptx-LNCs), to interpret the results in the light of LNC behavior at air-mucus interface (2D model). LNC surface properties were modified with chitosan or poly(ethylene glycol) (PEG) coatings of different size (PEG 2,000 to 5,000 Da) and surface charges. LNC diffusion through 446 μm pig intestinal mucus layer was studied using Transwell(®). LNCs were spread at the air-water-mucus interface then interfacial pressure and area changes were monitored and the efficiency of triglyceride (TG) inclusion was determined. Ptx-LNCs of surface charges ranging from -35.7 to +25.3 mV were obtained with sizes between 56.2 and 75.1 nm. The diffusion of paclitaxel in mucus was improved after encapsulation in neutral or positively charged particles (p < 0.05 vs Taxol(®)). No significative difference was observed in the 2,000-5,000 PEG length for diffusion both on the 2D or 3D models. On 2D model positive or neutral LNCs interacted less with mucus. Highest efficiency of TG inclusion was observed for particles with smallest PEG length. The results obtained with 2D and 3D model allowed us to select the best candidates for in vivo studies (neutral or positive LNCs with smaller PEG length).

Toxicological Study and Efficacy of Blank and Paclitaxel-Loaded Lipid Nanocapsules After i.v. Administration in Mice

Lipid nanocapsules (LNCs) are solvent-free drug nanocarriers permitting entrapment of paclitaxel and increasing its antitumoural effect in animal models after i.v. injection. The tolerance and efficacy of LNCs after repeated dose i.v. administration were assessed in mice. The maximum tolerated dose (MTD) and 50 percent lethal dose (LD50) were studied. Paclitaxel-loaded LNC formulation was given i.v. at the dose of 12 mg/kg per day for 5 consecutive days in comparison with blank LNCs and saline. Histological examination, complete blood counts and biochemical quantification were performed after a recovery of 7 days. Growth of NCI-H460 subcutaneous xenografts in nude mice receiving one of the aforementioned schedules was assessed. MTD and LD50 were determined by Irwin test. No mortality was observed in repeated injections studies. Histological studies revealed no lesions and no accumulation of lipids. Blood studies were normal. The tumoural growth was significantly reduced in the group treated by paclitaxel-loaded LNCs. The MTDs/LD50s of Taxol, paclitaxel-loaded LNCs and blank LNCs were 12/19.5, 96/216 and above 288/288 mg/kg, respectively. This study demonstrates that a five-day i.v. injection schedule of paclitaxel-loaded LNC dispersions induces no histological or biochemical abnormalities in mice and improves paclitaxel efficacy and therapeutic index in comparison with Taxol.

1208 Toxicity of systemic administration of blank and paclitaxel-loaded lipid nanocapsules in mice

Hes6 is a member of hairy/enhancer of split (Hes) family that plays a role in the cell proliferation and differentiation. Recently, we found that Hes6 is involved in the regulation of cell proliferation via p53-dependent pathway. In addition to the proliferating regions, brain regions where early post-mitotic neurons are enriched also exhibited Hes6 and p53 mRNA expression. Because p53 is involved in the post-mitotic neuronal apoptosis, here we investigated whether Hes6 can influence the neuronal survival/death. Overexpression of wild-type Hes6 and its mutants induced the apoptosis of primary cultured cortical neurons. In addition, neuronal apoptosis by Hes6 overexpression was markedly blunted in p53−/− or Bax−/− cortical neurons, suggesting that these pro-apoptotic effects are mediated by p53- and Bax-dependent pathway. However, transactivation-defective mutants of Hes6 also enhanced neuronal apoptosis, suggesting that apoptogenic activity of Hes6 is not directly related to its role in the transcriptional regulation. We propose that Hes6 may play a significant role in the neuronal cell death and/or pathological neurodegeneration via activation of p53 signaling.

Lipid nanocarriers improve paclitaxel transport throughout human intestinal epithelial cells by using vesicle-mediated transcytosis

The use of lipid nanocapsules (LNCs) has enabled an improvement of the oral bioavailability of paclitaxel (Ptx). However, mechanisms that support this recent observation are not yet understood. By focusing on the well defined in vitro Caco-2 model, the purpose of this study was to evaluate the transport of LNCs across a model intestinal barrier. Firstly, four sizes of paclitaxel or dye (Nile Red)-loaded LNCs were formulated and LNCs with sizes between 26.3 ± 2.7 nm and 132.7 ± 5.5 nm were obtained. Different transport and uptake experiments were then performed across a Caco-2 cells culture model using these LNCs. Paclitaxel-loaded LNCs improved permeability of Ptx across intestinal epithelium compared with free Ptx or Taxol ® by a factor of 3.5. At 37 °C particle size did not influence transport efficiency. However, at 4 °C a decrease in Ptx transport was observed with increasing size of LNCs. Thus, with LNCs of 25 nm size, the apparent permeability coefficient ( P app) was 5.3 ± 1.1 cm s − 1 at 37 °C and 2.2 ± 0.4 cm s − 1 at 4 °C. In comparison in LNCs of 130 nm size, the P app decreased from 5.8 ± 0.8 cm s − 1 at 37 °C to 0.5 ± 0.1 cm s − 1 at 4 °C. The uptake of LNCs by Caco-2 cells and the incapacity of LNCs to open tight junctions were also demonstrated. Furthermore, experiment transports were performed in the presence of different inhibitors of endocytosis. Findings indicated a reduction of Ptx transport of 30 ± 6% when cell cholesterol was depleted, 65 ± 12% when caveolae-mediated endocytosis was inhibited and 20 ± 8% when clathrin-mediated endocytosis was inhibited. Finally, transmission electronic microscopy showed the presence of nano-objects on the basolateral side of the Caco-2 cell monolayers when LNCs were applied on the apical side.

Lipid nanocapsules: Ready-to-use nanovectors for the aerosol delivery of paclitaxel

Aerosol drug delivery permits the development of dose-intensification strategies in severe, malignant lung diseases. The aim of the study was to demonstrate that the encapsulation of paclitaxel in lipid nanocapsules (LNCs), a novel drug nanocarrier for lipophilic components, allows one to provide pulmonary drug delivery of paclitaxel by nebulisation, thereby allowing preclinical and clinical studies. LNC dispersions are made into aerosols with commercial nebulisers. The structure, drug payload and cytotoxicity of nebulised LNCs were compared to fresh LNCs. The results demonstrated that LNC dispersions could be made into aerosols by using mesh nebulisers without altering the LNC structure. Only eFlow rapid-produced aerosols are compatible with human use: the mean duration to nebulise 3 ml of LNC dispersion is less than 9 min, with an aerosol mass median aerodynamic diameter equal to 2.7+/-0.1 microm and a fine-particle fraction (between 1.0 and 5.0 microm) of 81.5+/-3.1%. No modifications of drug payload or cytotoxicity effects of paclitaxel-loaded LNC (PTX-LNC) were observed. In order to carry out preclinical studies, a scaled-up LNC formulation protocol was used. Chemical parameters, such as acidity and osmolarity, were optimised, and a storage procedure for PTX-LNC batches was set-up. Animal studies are now needed to determine the tolerance and therapeutic potential of LNC dispersion aerosols.

The gastrointestinal stability of lipid nanocapsules

The in vitro gastrointestinal stability of lipid nanocapsules (LNCs) was studied in different media. The size of LNCs was determined in simulated gastric and intestinal media. In updated fasted state simulated intestinal fluid (FaSSIF-V2) and updated fed state simulated intestinal fluid (FeSSIF-V2) media, the encapsulation ratio of paclitaxel-loaded LNCs was also measured. The size of LNCs was not modified after 3 h in simulated gastric fluid and simulated intestinal fluid described by the United States Pharmacopeia, in FaSSIF, FaSSIF-V2, and in FeSSIF. Moreover, in the presence of pancreatin in FeSSIF-V2, a decreased above 30% of the loading of paclitaxel was observed. This was attributed to the presence of lipase in pancreatin that could interact with Lipoid ® (a mixture of phosphatidylcholine and phosphatidylethanolamine), present on the shell of LNC. As a conclusion, LNCs were stable on gastric medium and fasted state intestinal medium.

The adaptation of lipid nanocapsule formulations for blood administration in animals

In many cell-culture and animal models, the therapeutic effects of the entrapped drugs in lipid nanocapsules (LNCs) were preserved with low toxicity. These results allow foreseeing further preclinical efficiency and toxicity studies in animals. In this article, preliminary studies were performed to check the genetically modified organism (GMO) status of the LNCs components and to determine the effects of the acidity of the LNCs dispersions in acid–base balance in rats. Then, several freezing protocols to store paclitaxel-loaded LNCs dispersions for a 6-month period were compared. Results indicate that the Lipoïd ® S75-3 could not be certified GMO-free. The same soya bean lecithin certified to be GMO-free permitted to produce LNCs with expected characteristics. The blood administration of blank LNCs dispersions in rats induced no modifications of blood acidity, but a significant decrease of the base excess was observed. Injections of LNCs dispersions in animals might induce iatrogenic acidosis. We finally demonstrated that the best protocol to store LNCs dispersion for a 6-month period is by freezing in liquid nitrogen. This protocol minimized the characteristics modifications and interrupted the drug-release phenomenon. These original data are expected to prepare of LNCs dispersions well adapted for i.v. administration in animals.

In vivo evaluation of lipid nanocapsules as a promising colloidal carrier for paclitaxel

Paclitaxel-loaded lipid nanocapsules (PX-LNC) exhibit interesting in vitro characteristics with improved antitumoral activity compared with free PX formulation. Biodistribution studies were realized with the use of 14C-trimyristin ( 14C-TM) or 14C-phosphatidylcholine ( 14C-PC) whereas antitumoral activity of PX-LNC formulations was based on the animal survival in a chemically induced hepatocellular carcinoma (HCC) model in Wistar rats. Blood concentration–time profiles for both labeled 14C-TM-LNC and 14C-PC-LNC were similar; the t 1/2 and MRT values (over 2 h and close to 3 h, respectively, for both formulations) indicated the long circulating properties of the LNC carrier with a slow distribution and elimination phase. Survival curves of paclitaxel treated groups showed a statistical significant difference compared to the control survival curve ( P = 0.0036 and 0.0408). Animals treated with 4× 70 mg/m 2 of PX-LNC showed the most significant increase in mean survival times compared to the controls (IST mean 72%) and cases of long-term survivors were preferentially observed in the PX-LNC treated group (37.5%; 3/8). These results demonstrate the great interest to use LNC as drug delivery system for paclitaxel, permitting with an equivalent therapeutic efficiency to avoid the use of excipients such as polyoxyethylated castor oil for its formulation.

A new generation of anticancer, drug-loaded, colloidal vectors reverses multidrug resistance in glioma and reduces tumor progression in rats

By focusing on rat glioma, we elucidated whether new lipid nanocapsules (LNC) were able to improve anticancer hydrophobic drug bioavailability while also overcoming multidrug resistance. Blank LNCs and LNCs loaded with the antineoplastic agent paclitaxel were formulated by an emulsion inversion phase process. Expression of efflux pumps by rat glioma cells was assessed by reverse transcription-PCR, Western blot, and immunohistochemistry, and their activity was followed using the tracer (99)Tc(m)-methoxyisobutylisonitrile. Modalities of LNC action were addressed by using confocal microscopy detection of fluorescently labeled LNCs, fluorescence-activated cell sorting, high-performance liquid chromatography measurement of paclitaxel release, and analysis of tumor cell growth. This revealed an interaction between LNCs and efflux pumps that resulted in an inhibition of multidrug resistance in glioma cells, both in culture and in cell implants in animals. LNCs were able to target the intracellular compartment of glioma cells, a mechanism that was abrogated by using intracellular cholesterol inhibitors but not by clathrin-coated pit or caveolae uptake inhibitors. This result can be correlated to the LNC inhibitory effects on efflux pump activity that is itself known to be stimulated by intracellular cholesterol. In parallel, we showed that paclitaxel-loaded LNCs were active reservoirs from which paclitaxel could be released. Finally, we established that paclitaxel-loaded LNCs were more efficient than the commercially available paclitaxel formulation (Taxol) for clinical use, thus reducing tumor expansion in vitro and in vivo. Considering the physiologically compatible nature of LNC excipients, these data may represent an important step towards the development of new clinical therapeutic strategies against cancers.

Enhanced Oral Paclitaxel Bioavailability After Administration of Paclitaxel-Loaded Lipid Nanocapsules

The aim of this study was to evaluate the pharmacokinetics of paclitaxel-loaded lipid nanocapsules (LNC) in rats to assess the intrinsic effect of the dosage form on the improvement of paclitaxel oral exposure. Paclitaxel-loaded LNC were prepared and characterized in terms of size distribution, drug payload, and the kinetics of paclitaxel crystallization. Taxol, Taxol with verapamil, or paclitaxel-loaded LNC were administered orally to rats. The plasma concentration of paclitaxel was determined using liquid chromatography mass spectrometry. The average size of LNC was 60.9 +/- 1.5 nm. The drug payload of paclitaxel was 1.91 +/- 0.01 mg/g of aqueous dispersion. The encapsulation efficiency was 99.9 +/- 1.0%, and 1.7 +/- 0.1% of paclitaxel was crystallized after 24 h. The oral bioavailability of Taxol alone was 6.5%. After oral administration of paclitaxel-loaded LNC or paclitaxel associated with verapamil, the area under the plasma concentration-time curve was significantly increased (about 3-fold) in comparison to the control group (p < 0.05). The results indicated that LNC provided a promising new formulation to enhance the oral bioavailability of paclitaxel while avoiding the use of pharmacologically active P-gp inhibitors, such as verapamil.