Liquid Digestate Research Articles

Using process modeling and simulation to determine the sustainability of a novel lactic acid biorefinery in Europe: Influence of process improvements, scale, energy source, and market conditions

The biorefinery concept aims to produce multiple high-value products from bio-based feedstocks. One such product is lactic acid, which is used across several industries such as food, pharmaceuticals, cosmetics, and chemicals. Lactic acid yield is influenced by several factors, and improvements in performance are often first demonstrated at lab-scale, requiring prospective models which make assumptions about how the system will be optimized to understand the potential of a commercial-scale plant. This study assesses the economic and environmental sustainability of a proposed lactic acid biorefinery through the combination of process modelling, techno-economic assessment, and life cycle assessment. The case study proposes producing high purity lactic acid from industrial candy waste and liquid digestate in Denmark through lactic acid fermentation and downstream membrane separations. A base case is first modelled to determine the economic and environmental hotspots of the system; scenarios are then modelled where improvement methods are implemented reducing consumption of energy, chemicals, water, and the production of waste, upscaling the system, and integrating bioenergy. Finally, a cost sensitivity analysis is run varying bioenergy, water, chemical, and labor costs based on the European market. By optimizing unit processes, scale, energy sources and market conditions, the lactic acid unit production cost and global warming potential can be lowered by 94% and 80% compared to the base case, respectively. However, these are optimized in different scenarios, indicating a trade-off in optimizing economic and environmental criteria. As even best-case lactic acid unit production cost is found to be 141–232% higher than market price, this production pathway will require further improvement or market changes before it can be commercially viable.

Bioaugmented ensiling pretreatment to improve bioconversion of sweet sorghum: Effect of bio-additives on enzymatic saccharification and biomethane potential

This study proposes a novel strategy to integrate ensiling preservation with pretreatment of sweet sorghum (SS) biomass. Bio-additives, including cellulase, xylanase, liquid anaerobic digestate (LD), and rumen fluid (RF) were applied in ensiling process to improve the silage quality, sugar production by enzymatic hydrolysis, and anaerobic biomethane production of SS. Compared with others additives, LD could alter microbial community compositions and reduce the crystallinity of SS, thus improving ensiling pretreatment performance and achieving the highest reducing sugar yield of 84.73%. The methane production of LD silages was increased by 32.84% compared with the un-ensiled SS, indicating that ensiling pretreatment with LD could be an effective strategy to achieve the trans-seasonal preservation and improving the methane production of SS. Furthermore, taking techno-economic factors into account (energy net income of 96.07 USD/ton), LD additive was recommended for the bioaugmented ensiling pretreatment and downstream methane production of SS, which also contribute to recirculate the liquid digestate from biogas plant.

Simultaneous analysis of depurinated nucleic acid stem-loop and free adenine for ricin toxicity assay by hydrophilic interaction liquid chromatography-high-resolution mass spectrometry (HILIC-HRMS).

A simple, accurate method for measuring ricin activity was developed by detecting depurinated nucleic acid stem-loops and adenine using a commercially available hydrophilic interaction liquid chromatography (HILIC) column and a quadrupole-Orbitrap tandem mass spectrometer. Ricin in beverages was isolated using magnetic beads conjugated with ricin B-chain antibodies, and then incubated with a 14 mer RNA or a 12 mer RNA/DNA chimera, in which adenosine at the depurination site of RNA was replaced by deoxyadenosine. The adenine and depurinated nucleic acids were separated by HILIC and both analytes were detected by high-resolution mass spectrometry. The depurinated RNA was detectable at concentrations as low as 100 pM (6.5 μg mL-1) in orange juice and coffee, and 10 pM (0.65 μg mL-1) in milk and sake after incubation with the RNA substrate for 4 h. Free adenine was detectable at 10 pM in all matrices, although free adenine was also detected in all blanks and could not be distinguished from the coffee and orange juice blanks at 10 pM. When using the chimera as the substrate, the depurinated chimera and adenine were detected up to concentrations of 10 pM as larger peaks. However, since the depurinated chimera and adenine were also detected in blanks, careful judgment was needed to determine whether they were active. Following the assay, the captured ricin could be analyzed by enzymatic digestion and nano liquid chromatography-high-resolution mass spectrometry. The ricin A chain-specific T7A peptide was detectable at 10 pM for sake and at 100 pM for milk, orange juice, and coffee. Using the present method, a toxicity assay and qualitative analysis of ricin were feasible with a 0.2 mL beverage sample.

Enhancing nutrient water recovery: An integrated electrodialysis – Forward osmosis approach for reduced energy consumption and membrane fouling

The concept of combining electrodialysis (ED) and forward osmosis (FO) was previously introduced and proven effective in recovering nutrients and clean water from anaerobic effluents to produce safe liquid fertilizer. In this study, a novel and improved EDFO configuration (iEDFO) was proposed by merging the ED diluate with the FO feed solution and the ED concentrate with the FO draw solution, thus overcoming concentration limitations and fouling challenges inherent in traditional ED processes. Experimental results demonstrated significant improvements in performance, including up to 54 % and 43 % reductions in operation time and 21 % and 25 % energy savings for synthetic and real liquid digestate, respectively. These enhancements were attributed to altered ionic composition within the ED process, leading to higher, more stable current density and reduced ion back diffusion. Unlike conventional ED-only systems, the iEDFO configuration enabled continuous operation without requiring larger membrane areas or variable operational conditions. Additionally, the iEDFO configuration benefited from (1) reduced membrane fouling, and (2) decreased transport of organic contaminants across the anion exchange membranes (AEMs) into the ED concentrate product. Overall, the iEDFO system provides significant advantages in efficiency, energy savings, and operational stability, making it a highly effective and sustainable solution for resource recovery from liquid waste.

Jerusalem Artichoke: Nitrogen Fertilization Strategy and Energy Balance in the Production Technology of Aerial Biomass

Jerusalem artichoke (Helianthus tuberosus L.) is a plant with considerable potential for energy generation due to its rapid growth, high biomass yield, and resistance to environmental stresses. The aim of this study was to determine the influence of the nitrogen fertilization strategy on the yield and energy balance in the production technology of Jerusalem artichoke (JA) in a perennial cropping system. The article presents the results of a three-year experiment which was conducted in Poland to determine the effect of different N rates (0, 50, 75, and 100 kg ha−1) supplied with mineral fertilizers and liquid digestate on the energy balance in the production of JA aerial biomass. The experiment had a randomized block design with three replications. The demand for energy in JA cultivation reached 16.2–26.3 (year 1) and 2.9–14.6 GJ ha−1 (years 2 and 3). Energy inputs in the cultivation technology were reduced by 17–19% (year 1) and 35–47% (years 2 and 3) when mineral fertilizers were replaced with digestate. Jerusalem artichoke yields were lowest in the technology without fertilization (12.5 Mg ha−1 DM). Dry matter yield increased significantly (by 43–55%) after the application of 75 kg N ha−1, regardless of fertilizer type. The energy output of biomass peaked (230.1 GJ ha−1) in response to a mineral fertilizer rate of 75 kg N ha−1. In turn, the highest energy gain (218.5 GJ ha−1) was noted after the application of digestate at a rate equivalent to 75 kg N ha–1. The energy efficiency ratio was highest in the technology without fertilization (20.1) and after the application of digestate at a rate equivalent to 75 kg N ha−1 (19.7). Regardless of the factors that limit agricultural production, the energy balance of JA biomass production was most favorable when JA was fertilized with digestate at a rate equivalent to 75 kg N ha−1. The results of this study may pave the way for future research on novel agronomic strategies for sustainable bioenergy production, including nutrient recycling.

Treating liquid anaerobic digestate using natural zeolite and Arthrospira platensis cyanobacteria: From laboratory to pilot-scale

Over the past decade, using liquid digestate as a nutrient source for microalgae cultivation has gained considerable attention. However, its high ammonium concentration and turbidity often inhibit algal growth. To address this, natural zeolite was explored as a novel approach to reduce digestate toxicity before microalgae cultivation at both laboratory and pilot-scales. Clinoptilolite, a type of natural zeolite, was applied in adsorption columns at a ratio of 0.5 kgzeolite.L-1 to treat 0.45 L of liquid digestate. After 24 h of treatment, ammonium levels decreased significantly from 2273 to 115 mgN.L-1, corresponding to a 95 % removal efficiency and an adsorption capacity of 4.31 mg.gzeolite-1. Arthrospira platensis demonstrated strong growth in the treated digestate with minimal dilution (≤5x), in contrast to the high dilution (≥20x) required for the untreated digestate. Laboratory-scale results were effectively scaled up to pilot scale, detoxifying 15.5 L of digestate with similar performances. The pretreated digestate was subsequently used as a culture medium for Arthrospira platensis in flat panel photobioreactors without further dilution, achieving a final concentration of 0.82 gDW.L-1 and a biomass productivity of 33 mg.L-1.d-1. These findings underscore the potential of natural zeolite in enhancing microalgae-based processes for digestate detoxification and CO2 mitigation.

Microbial diagnostics unveil key driver bacteria and methanogens associated with system stability and biogas production in food waste anaerobic digestion systems

Microorganisms play an important role in the methane-producing anaerobic digestion system (ADS) of food waste. But what are the key microbes? How they participate in the regulation to maintain the stability and efficiency of the ADS remains unclear. In this study, the microbial community structure of anaerobic digestion liquid samples from five stably operating ADS was analyzed using Illumina NovaSeq high-throughput sequencing. The exploration of the species composition and co-occurrence network relationships of microorganisms revealed that Fermentimonas, DTU014, Syntrophomonas, Thermovirga, Methanothrix and Methanobacterium were indicative microorganisms associated with ADS stability. With the investigation of the correlation between microbiological factors and biogas yield, Anaerolinea, Gelria, W5053, Pelotomaculum, Syntrophaceticus, Syntrophomonas, Tepidanaerobacter, Methanomassiliicoccus, Methanothrix, and Methanobacterium exhibited a significant positive response in biogas yield. Among them, Fermentimonas caenicola, Syntrophaceticus schinkii, Syntrophomonas wolfei, Methanobacterium formicicum, and Methanothrix soehngenii were identified as the core functional strains related to efficient biogas production. Biogas yield was mainly influenced by the community structure of bacteria (total effect = −1.463) and methanogens (total effect = −1.511). The findings reveal key drivers of biogas yield, deepen understanding of the application of microbial data in ADS, and provide a theoretical basis for using microbial resources to support bioenergy development.

Optimizing the performance parameters of vacuum evaporation technology for management of anaerobic digestate in a waste water treatment plant using fuzzy MCDM method

Evaporation technology in waste water treatment plants is used to treat excess liquid digestate, eventually reaping the essential nutrients from the process. In the present study, the input conditions have been optimized for implementing and achieving optimal performance of the digestate evaporation technology used in waste water treatment plants by employing fuzzy multi-criteria decision making method. Three input parameters, namely the Temperature, the Pressure, and the Mass Flow rate, each at three levels are considered. Experiments are conducted as per the Taguchi’s L9 standard orthogonal array. The performance of the evaporator is examined based on a few response characteristics, such as payback period, thermal energy consumption, power consumption and cost per unit of electricity. Temperature's impact on multi performance stands out significantly, contributing the most (70.52 %), followed by mass flow rate (18.95 %), and pressure (5.37 %). Result of the study reveals that within the investigated range of input parameters, temperature at 80 ℃, pressure at 0.3 bar and mass flow rate at 20 kg/h is the optimal combination. The results of the present study will help in enhancing the efficiency and effectiveness of the evaporation process, leading to improved digestate treatment that supports circular economy initiatives.

Purification of Liquid Fraction of Digestates from Different Origins-Comparison of Polymeric and Ceramic Ultrafiltration Membranes Used for This Purpose.

Circular economy, clean technologies, and renewable energy are key to climate protection and modern environmental technology. Recovering water and valuable minerals from the liquid fraction of digestate is in line with this strategy. Digestate, a byproduct of anaerobic methane fermentation in biogas plants, is a potential source of water, minerals for fertilizers, and energy rather than waste. This study examined digestate from municipal and agricultural biogas plants and highlights the need for research on both due to their differences. The use of membrane techniques for water recovery from liquid digestate offers an innovative alternative to conventional methods. This study used standalone membrane filtration and an integrated system to produce water suitable for agricultural use. Ceramic membranes with cut-offs of 1, 5, 15, and 50 kDa and polymeric membranes of polyethersulfone and regenerated cellulose with cut-offs of 10 and 30 kDa were tested. The results showed that the membrane material significantly affects the transport and separation properties. Higher cut-off values increased permeate flux across all membranes. Ceramic membranes were more susceptible to fouling in standalone ultrafiltration, but were more effective in purifying digestate than polymeric membranes. The best results were obtained with a ceramic membrane with a 1 kDa cut-off (for example, for the integrated process and the municipal digestate, the retention rates of COD, BOD5 and DOC were 69%, 62%, and 75%, respectively).

Ammonia oxidizing bacteria (AOB) denitrification and bacterial denitrification as the main culprit of high N2O emission in SBR with low C/N ratio wastewater

A large amount of greenhouse gas nitrous oxide (N2O) will be produced during the biological nitrogen removal process for organic wastewater of low C/N ratio. One of the effective methods to solve this problem is to incorporate inexpensive carbon source. In this study, raw wastewater (RW) from pig farm, that was not anaerobically digested, was utilized as exogenous carbon in both A/O and SBR aerobic reactor to treat liquid digestate with high ammonia nitrogen and low C/N ratio. The results showed that N2O emission in SBR was higher than that of A/O process under the same nitrogen load. The N2O conversion in the biological nitrogen removal process was investigated by the strategy of integrating stable isotope method and metagenomics. The δO18-N2O, δN15-N2O, and SP values of the SBR were closer to the denitrification values of Ammonia-Oxidizing Bacteria (AOB) than those of A/O. The abundance of AOB in the SBR reactor was higher than that in the A/O reactor, while the abundance of denitrifying bacteria was lower. The amoA/B/C gene abundance in the SBR was greater than that in the A/O, and the NOS gene abundance was the opposite. The results indicated that both AOB denitrification and bacterial denitrification led to the increase of N2O emissions of the SBR.

Selective electrodialysis for nutrient recovery and pharmaceutical removal from liquid digestate: Pilot-scale investigation and potential fertilizer production

The present research employs a pilot-scale selective electrodialysis system to treat liquid digestate, fractionating nutrient ions and exploring fertilizer creation via ammonia stripping and phosphorus precipitation, while studying pharmaceutical transport behavior and examining membrane fouling. The influence of diverse potentials was studied in simulated and real digestate, with 30 V application proven more efficient overall. Applying consecutive runs resulted in products that were 7.9, 7.4, 1.7, 5.3, and 6 times more concentrated compared to the feed solution for NH4+, K+, PO43-, Ca2+, and Mg2+, respectively. Pharmaceuticals analysis showed that ciprofloxacin was completely retained in the liquid digestate, while ibuprofen was detected in the anionic product. Diclofenac was initially present in the digestate but was undetectable in the final products, suggesting it adhered to the membrane. Membranes showed inorganic and organic fouling. The monovalent cation exchange membrane had severe salt scaling, showing calcium and magnesium deposits, and fewer functional groups.

Biogas liquid digestate application: influence on soil microbial biomass and CO2 respiration

Biogas liquid digestate application: influence on soil microbial biomass and CO2 respiration

Energy efficiency of Silphium perfoliatum and Helianthus salicifolius biomass production

Silphium perfoliatum L. and Helianthus salicifolius A. Dietr are perennial herbaceous crops (PHC) that have recently attracted much attention. This study aimed to determine the energy input, the yield energy value, and the biomass production energy efficiency for the two prospective PHC species depending on the type of fertilizer (liquid digestate and mineral fertilizers) and the nitrogen fertilization level (0, 85 and 170 kg ha−1 N) in three consecutive growing years (2019–2021). S. perfoliatum produced a 14.1 % higher biomass yield energy value (142.3 GJ ha−1 y−1 on average) than H. salicifolius. However, the production of S. perfoliatum also required 22.8 % higher mean energy input (11.3 GJ ha−1 y−1) compared to H. salicifolius. As a result, the mean energy ratio for H. salicifolius (15.2) was 8.6 % higher than for S. perfoliatum. The highest energy ratios for H. salicifolius and S. perfoliatum were 29.7 and 22.8, respectively. Liquid digestate and mineral fertilization resulted in an increase in the yield energy value compared to plots with no fertilization, but at the same time, it increased the energy input. Therefore, the energy ratio in control plots was higher compared to the variants with fertilization.

Enhanced growth of benthic microalgae by tablet from liquid dairy cattle manure-based anaerobic digestate

An effective strategy for utilizing anaerobic digestates is required to promote biomass power generation. We developed an anaerobic digestate tablet using liquid dairy cattle manure derived from a small mesophilic anaerobic digester installed on a dairy farm. Anaerobic digestate tablets are intended for use in the fertilization of oligotrophic coastal seas to promote primary production. The purpose of this study was to evaluate (1) the dissolution behavior of nutrients from anaerobic digestate tablets and (2) the effect of the application of anaerobic digestate tablets on the growth of benthic microalgae using a culture experiment. Batch experiments were conducted to investigate the dissolution behavior of the nutrients. Cumulative amounts of dissolved inorganic nitrogen and phosphate in the anaerobic digestate tablet ranged from 110 to 28.9 μg g−1 after 28 days. The dissolved inorganic nitrogen in the anaerobic digestate tablet was mainly ammonium nitrogen and accounted for 92.4–96.9%, which is advantageous for the growth of microalgae. The growth curve of the benthic microalga Nitzchia longissima was monitored using f/2 medium added to the anaerobic digestate tablet. The growth of Nitzchia longissima was two orders of magnitude greater than that of the positive control. The enhanced growth of Nitzchia longissima by the anaerobic digestate tablet was considered a concomitant effect of moderate dissolution of ammonium nitrogen and high affinity for benthic microalgae. In conclusion, the anaerobic digestate tablets prepared in this study have the advantage of supplying nitrogen to benthic microalgae. This study proposes a new method for utilizing anaerobic digestates.

A sustainable, zero-waste approach for production of biohydrogen from chicken manure slurry by hybrid recycling of digestate

This study provides a sustainable approach to produce biohydrogen through the long-term hydrogenic fermentation of chicken manure (CM) in a semi-continuous stirred tank reactor (CSTR) under different organic loading rates (OLRs). To ensure the zero-waste route and sustainability, the total digestate was mechanically separated into liquid and solid fractions. The solid digestate fraction was thermally treated to produce biochar, while the liquid digestate fraction was biologically treated through bioaugmentation with a novel heterotrophic nitrification-aerobic denitrification (HD-AN (bacterial strain (Alcaligenes sp. ME-1). The results showed that the high concentration of free ammonia nitrogen (FAN) contents of CM could inhibit methanogenesis and induce hydrogen production. The ORLs of 2.5, 3.5, 4.5, and 5.5 gVS/L.d imposed to the CSTR resulted in volumetric hydrogen production (VHP) of 643.3 ± 37, 908.8 ± 64.5, 1077.8 ± 95.17, and 1383.3 ± 156.8 mL/L.d, respectively. The microbial community structures indicated the long-term adaptation of hydrogen-producing bacteria and methanogenesis inhibition. The bioaugmentation process removed 83.3 % of total ammonia and 66.2 % of the chemical oxygen demand (COD) from the liquid digestate fraction. The characteristics of the biochar derived solid digestate is suitable for land applications as fertilizer. The hybrid approach combining biohydrogenation, pyrolysis, and bioaugmentation, maximizes the utilization of chicken manure slurry while conforming to the sustainable development goals.

Deciphering the anammox microbial community succession with humic acid exposure to optimize large anammox granules for robust nitrogen removal

The robustness of the anaerobic ammonia oxidation (anammox) process in treating wastewater with high concentrations of humic acids (HAs), including landfill leachate and sludge anaerobic digestion liquid, has been paid great attention. This study revealed that the anammox sludge granule size of 1.0–2.0 mm could be robust under the HA exposure with high concentrations. The total nitrogen removal efficiency (NRE) was 96.2% at the HA concentration of 20–100 mg/L, while the NRE was 88.5% at the HA concentration of 500 mg/L, with reduced by 7.7%. The increased extracellular polymeric substances (EPS) content which was stimulated by the HA exposure favored the formation of large granules (1.0–2.0 mm) by enveloping medium and micro granules (0.2–1.0 mm). The abundance of anammox bacteria Candidatus Brocadia was found to be higher (14.2%) in large anammox granules sized 1.0–2.0 mm, suggesting a potentially high anammox activity. However, the abundance of denitrifiers Denitratisoma increased by 4.3% in ultra-large anammox granules sized >2.0 mm, which could be attributed to the high EPS content for heterotrophic denitrifiers metabolism as organic matter. The feedback mechanism of the anammox community for maintaining the ecological function under the HA exposure resulted in a closely related microbial community, with positive and negative correlations in the ecological network increased by 64.3%. This study revealed that the HA exposure of the anammox system resulted in the anammox granules of 1.0–2.0 mm size being the dominant granules with robust nitrogen removal, providing significant guidance for the optimization of anammox granules for an efficient treatment of HA-containing wastewater in anammox applications.

Production of Poly(3-hydroxybutyrate-co-3-hydroxyvalerate) by Bacillus megaterium LVN01 Using Biogas Digestate

The Bacillus megaterium LVN01 species native to Colombia has demonstrated the ability to metabolize different coproducts or industrial waste (such as fique juice, cane molasses, and residual glycerol) and accumulate polyhydroxybutyrate (PHB), giving it potential in the bioplastics industry. In this research, the potential of liquid digestate as a carbon source for the production of PHA polymers in fermentation processes with this bacterial strain was evaluated. Favorably, it was found that B. megaterium utilizes the nutrients from this residual substrate to multiply appropriately and efficiently synthesize poly(3-hydroxybutyrate-co-3-hydroxyvalerate) (PHBV). Bench-scale aerobic batch fermentation, under the operational conditions of this research [volume: 3 L; temperature: 30.8 °C; agitation: 400 rpm; pH: 7.0 ± 0.2; dissolved oxygen: 100% saturation; antifoam: 10% (v/v)], generated maximum values of dry cell weight (DCW) (0.56 g cell L−1) at 60 h, while the maximum PHBV yield (360 mg PHBV L−1) occurred at 16 h, which is very favorable for sustainable degradable bioplastics production. Additionally, GC–MS and NMR analyses confirmed that the PHBV copolymer synthesized by B. megaterium is made up of the monomers 3-hydroxybutyrate (3HB) and 3-hydroxyvalerate (3HV). Furthermore, the thermal properties determined by TGA (Tonset = 283.1 °C; Tendset = 296.98 °C; Td = 290.114 °C) and DSC (Tm = °C 155.7 °C; ΔHf = 19.80 J g−1; Xcr = 18.17%) indicate that it is a thermally stable biopolymer with low percentages of crystallinity, providing flexibility that facilitates molding, adaptation, and application in various industrial sectors.

An Integrated Process of Struvite Precipitation/Membrane Filtration Using Flat Ceramic Membranes Is an Effective Method for the Treatment of Liquid Fraction Digestate from a Municipal Biogas Plant

One method of processing municipal waste biogas plant digestate is to separate it into solid and liquid fractions. Since the digestate can be a potential source of water, it must undergo the appropriate treatment. Pressurised membrane processes preceded by struvite precipitation can be particularly useful in this regard. Experiments were conducted to determine the effectiveness of treating the digestate liquid fraction from a municipal waste biogas plant using an integrated process that combines struvite precipitation with membrane filtration, employing flat ceramic membranes with different cut-off values. The results confirm that this integrated process is effective for digestate treatment. A significantly increased improvement in the final quality of the test solution and a reduction in membrane fouling intensity were observed compared to those of these processes conducted separately. It is noteworthy that the purest solution was obtained when struvite precipitation and filtration through a flat ceramic membrane with a cut-off of 1 kDa were combined. This approach enabled the precipitation of struvite, a valuable fertiliser; the protection of the membranes from fouling; and a high degree of organic compound removal. The recovered water from the digestate (after dilution or removal of excess salts) can be used in agriculture or horticulture.

Enhanced anaerobic digestion of prairie biomass through alkaline-based hydroxycinnamic acid extraction

This study explores the hydroxycinnamic acid extraction from prairie biomass as a potential value-added pretreatment for enhancing the performance of anaerobic digestion. Pretreatment increased the biomethane potential of prairie biomass by 33 %; when the extraction residue was left on the biomass, the biomethane potential increased by 100 %. When the treated biomass was co-digested with manure, a 134 % and 25 % increase in methane productivity and methane content was obtained, respectively, relative to raw biomass co-digested with manure. Hydroxycinnamic acid extraction also improved anaerobic digestion performance under biochar supplementation and liquid digestate recirculation conditions. Lastly, the extraction process was optimized for hydroxycinnamic acid yield. It was found that increases in treatment temperature and time could further increase yield by 5 %. Collectively, the results show hydroxycinnamic acid extraction can be used as a highly effective pretreatment for improving the anaerobic digestion of prairie biomass.

Transforming waste to wealth: Impact of food waste‐derived soil amendments and synthetic nitrogen fertilizer on soil dynamics

AbstractApproximately one‐third of all food produced globally goes to waste, highlighting the need for sustainable waste management technologies like composting and anaerobic digestion. These technologies convert food waste into soil amendment products such as compost, liquid digestate (LD) and solid digestate (SD). However, these food waste‐derived soil amendments have relatively low nutrient contents compared with synthetic nitrogen (N) fertilizers such as urea, making their agricultural use challenging. Despite this, food waste‐derived soil amendments can enhance the physical and biological properties of soil, potentially creating synergistic effects when combined with synthetic N fertilizers. This study aimed to investigate effects of food waste‐derived amendments in soil applied at 50 kg ha−1 total N (compost, LD or SD) and synthetic N fertilizer [urea ammonium nitrate (UAN)] at 50 and 100 kg ha−1 total N. Over 56 days of soil incubation, greenhouse gases (CO2, N2O), soil chemistry (–N, –N, pH) and microbial biomass C (MBC) were measured. Results showed that LD + UAN 50 reduced cumulative N2O emissions by 23% compared with UAN 100, despite having the same total N and similar available N rate applied to soil. Replacing UAN with LD in farming practices can supply equivalent available N while lowering N2O emissions, offering a sustainable nutrient strategy. Moreover, applying food waste‐derived soil amendments can enhance N retention in soils, reducing the need for increased applications of synthetic N fertilizers to compensate for N deficits in farming. Food waste‐derived soil amendments can also act as a slower N release compared with UAN, reducing nitrogen run‐off. SD had the highest CO2 emissions, followed by LD and compost. SD + UAN 50 increased MBC levels because of higher carbon content and labile carbon, and available N because of the application of UAN. The major drawback of using SD compared with LD is that the process of evaporating LD to form SD causes high ammonia volatilization (ammonium in solution into ammonia gas) rates, reducing the available N in SD. Therefore, future studies should explore strategies to reduce ammonia volatilization of LD.