Utilizing rice straw and sugarcane bagasse as low-cost feedstocks towards sustainable production of succinic acid

Abstract

Succinic acid (SA) has been produced from rice straw (RS) and sugarcane bagasse (SB) as low-cost feedstocks in this study through sequential peracetic acid (PA) and alkaline peroxide (AP) pretreatment assisted by ultrasound and pre-hydrolysis followed by simultaneous saccharification and fermentation (PSSF). The effect of yeast extract (YE) concentration, inoculum concentration, and biomass type on SA production was investigated. The results showed that SA production from RS and SB was significantly affected by the YE concentration. Final concentration and yield of SA produced were significantly increased along with the increasing of YE concentration. Moreover, inoculum concentration significantly affected the SA production from SB. Higher inoculum concentration led to higher SA production. On the other hand, SA production from RS was not significantly affected by the inoculum concentration. Using RS as the feedstock, the highest SA production was achieved on the medium containing 15 g/L YE with 5 % v/v inoculum, obtaining SA concentration and yield of 3.64 ± 0.1 g/L and 0.18 ± 0.05 g/g biomass, respectively. Meanwhile, the highest SA production from SB was acquired on the medium containing 10 g/L YE with 7.5 % v/v inoculum, resulting SA concentration and yield of 5.1 ± 0.1 g/L and 0.25 ± 0.05 g/g biomass, respectively. This study suggested that RS and SB are potential to be used as low-cost feedstocks for sustainable and environmentally friendly SA production through ultrasonic-assisted PA and AP pretreatment and PSSF.