Total Contact Casting for Diabetic Foot Ulcers in Partial-Foot Amputations.

There is a growing body of evidence implicating obesity as having a negative effect on the development and treatment of diabetic foot disease. The aim of this study was to increase the body of knowledge on the effects of obesity on foot function, specifically as it relates to peak plantar pressures in the total contact cast (TCC). Our investigational objectives were to compare the effect of two different TCC designs on mean peak plantar pressures, and to evaluate the efficacy of two TCC constructs with increasing body mass. The primary outcome measure was mean peak plantar pressure in the heel, midfoot, forefoot and first metatarsal as measured with an in-shoe pressure measurement system. The variables were patient weight (from 'normal' body mass index (BMI) to 'overweight', 'obese' and 'morbidly obese') and the TCC construct (with both a standard and alternate cast design). The standard TCC is considered the gold standard for off-loading of the diabetic foot. The alternate TCC was designed to use the essential offloading component of the traditional TCC, namely the total contact leg section, with use of an open cell polyurethane foam to transfer load from the foot to the lower leg, thereby offloading the foot by suspending it within a padded fiberglass walking cast. We did not observe statistically significant differences in mean peak plantar pressures in any plantar foot anatomic area or with any body mass between the two TCC designs. Based on the results, we concluded that the alternate TCC design provides another viable TCC construct option for practitioners working with the neuropathic foot. This investigation also provides specific data on changes that occur in peak plantar pressures with use of the total contact cast and variable BMIs. none.

Quality of Life in Healing Diabetic Wounds: Does the End Justify the Means?

Category: Ankle, Diabetes, Lesser Toes, Midfoot/Forefoot Introduction/Purpose: Maximal limb preservation is often the goal in choosing partial foot amputation (PFA) as a treat-ment for diabetic foot infections. Some of these patients will go on to experience multiple hospital admissions, IV antibiotic courses, surgical debridements, re-amputations and other medical compli-cations. This study describes the treatment course of these patients starting at second partial foot amputation and ending at 5 year follow-up. Methods: A retrospective cohort was built from a database of all amputation procedures performed on diabet-ic patients at the University of Iowa Department of Orthopedics from 2000 – 2015. The cohort was evaluated over time frame starting at second PFA (index procedure) and ending at 5 years after in-dex procedure. Of 264 patients who underwent partial foot amputation, 49 experienced two lower extremities PFA between January 2000 and December 2011 (cut-off used to allow minimum of 5 years post-PFA). Demographic data was recorded at index PFA and included surgical dates, laterali-ty, surgery type, diagnoses at time of initial surgery, and death date. A chart review collected in-formation on 5 year post-index PFA incidence of: non-surgical hospitalizations, antibiotic admin-istrations, total contact cast applications, and complications (such as osteomyelitis and acute renal failure). Results: Thirty-two (65%) of the second partial foot amputations (index) were ipsilateral and 17 were con-tralateral to first partial foot amputation (pre-index procedure). Eighteen (37%) of the partial foot amputation patients eventually experienced transtibial / transfemoral amputations in the 5 years fol-lowing index PFA. Eleven (22%) had at least a third partial foot amputation (and as many as 7) dur-ing study period. Sixteen (32%) patients had 17 transtibial / transfemoral amputations within 5 year time frame. 11 of the 17 (65%) TT / TF procedures were ipsilateral to index (second) PFA. Seven (17%) of the patients died. Conclusion: Maximal limb preservation may not be beneficial in all cases, particularly in the case of repeat PFAs. This cohort of repeat PFA patients demonstrated a complicated medical course with long pe-riods of hospitalization, leg immobilization in cast, and home-going antibiotics (requiring PICC). This study suggested that over a 5 year period following second PFA, patients on average experi-enced at least 31 days in TCC, 17 days hospitalized and underwent one additional amputation pro-cedure. These are likely underestimates due to follow-up or outside hospital cares. A large number of patients (18 or 37%) ultimately required higher-level amputation. There is a potential morbidity with PFA that may not be communicated to patients when making these decisions. In this cohort, the average days to second PFA was 360 days. 18 of 49 repeat PFA patients underwent tran-stibial or transfemoral amputation within 5 years of their initial PFA. The morbidity of the interim medical course over 5 years added to the poor quality of life after PFA.

Difficulties in recruiting subjects with partial foot amputations for kinesiological research

<i>Background</i> Diabetic foot ulcers represent one of the most persistent and complex complications in clinical management. These ulcers pose significant challenges, often leading to morbidity and impaired mobility. Total contact casts (TCC) are often utilized in treatment for diabetic foot ulcers. A TCC may result in a functional iatrogenic limb length discrepancy (LLD) due to the inherent structure and material composition of the cast. While a TCC is effective in offloading pressure from affected diabetic foot ulcers and promoting healing, it may also alter gait mechanics and pressure distribution, affecting the contralateral limb. Recognizing and addressing these consequences is crucial for developing comprehensive treatment strategies that not only facilitate wound healing but also preserve functional mobility and prevent secondary complications. The central questions guiding this research are: What is the impact of a TCC-induced Leg Length Discrepancy (LLD) on contralateral limb loading? Can a contralateral lift effectively mitigate these effects? <i>Methods</i> We conducted a study involving thirty healthy adults (16 female, 14 male; mean age 26.5 years). Gait analysis was conducted using a CAREN instrumented treadmill under four experimental conditions: (1) Baseline: shoes only (no cast or lift); (2) TCC: TCC on the right foot, no lift on the left; (3) TCC+Heel: TCC on the right foot, heel lift in the left shoe; and (4) TCC+Full: TCC on right foot, full-length shoe lift on the left. The TCC introduced an approximate 1.9 cm limb length discrepancy (LLD). Gait parameters and ground reaction forces (GRFs) were recorded and analyzed using repeated-measures ANOVA to assess the effects of TCC and lift conditions on contralateral limb loading. <i>Results</i> Key outcomes included walking with a TCC (without a lift) increased peak contralateral foot GRFs by approximately 6% (p<0.05), indicating greater stress on the non-casted foot. Introducing a contralateral heel lift significantly reduced contralateral GRFs (p<0.01), suggesting partially restoring of normal loading patterns. However, a full-length shoe lift did not provide a comparable reduction in contralateral limb loading, showing no statistically significant benefit. <i>Significance </i>This study highlights the importance of recognizing a TCC-induced LLD increases contralateral limb loading. This study demonstrates that a simple contralateral heel lift effectively reduces excess loading and improves gait symmetry, whereas a full-length shoe lift offers little benefit. These findings support the routine use of heel lifts as an adjunctive measure during TCC treatment to improve gait symmetry and protect the non-casted limb.

Foot Care

BackgroundDysvascular partial foot amputation (PFA) is a common sequel to advanced peripheral vascular disease. Helping inform difficult discussions between patients and practitioners about the level of PFA, or the decision to have a transtibial amputation (TTA) as an alternative, requires an understanding of the current research evidence on a wide range of topics including wound healing, reamputation, quality of life, mobility, functional ability, participation, pain and psychosocial outcomes, and mortality. The aim of this review was to describe a comprehensive range of outcomes of dysvascular PFA and compare these between levels of PFA and TTA.MethodsThe review protocol was registered in PROSPERO (CRD42015029186). A systematic search of the literature was conducted using MEDLINE, EMBASE, psychINFO, AMED, CINAHL, ProQuest Nursing and Allied Health, and Web of Science. These databases were searched using MeSH terms and keywords relating to different amputation levels and outcomes of interest. Peer reviewed studies of original research—irrespective of the study design—were included if published in English between 1 January 2000, and 31 December 2015, and included discrete cohort(s) with dysvascular PFA or PFA and TTA. Outcomes of interest were rate of wound healing and complications, rate of ipsilateral reamputation, quality of life, functional ability, mobility, pain (i.e., residual limb or phantom pain), psychosocial outcomes (i.e., depression, anxiety, body image and self-esteem), participation, and mortality rate. Included studies were independently appraised by two reviewers. The McMaster Critical Review Forms were used to assess methodological quality and identify sources of bias. Data were extracted based on the Cochrane Consumers and Communication Review Group’s data extraction template by a primary reviewer and checked for accuracy and clarity by a second reviewer. Findings are reported as narrative summaries given the heterogeneity of the literature, except for mortality and ipsilateral reamputation where data allowed for proportional meta-analyses.ResultsTwenty-nine unique articles were included in the review, acknowledging that some studies reported multiple outcomes. Eighteen studies reported all-cause proportionate mortality. A smaller number of studies reported outcomes related to functional ability (two), mobility (four), quality of life (three), ipsilateral reamputation (six) as well as wound healing and complications (four). No studies related to pain, participation or psychosocial outcomes met the inclusion criteria. Subjects were typically older and male and had diabetes among other comorbidities. More detailed information about the cohorts such as race or sociodemographic factors were reported in an ad hoc manner. Common sources of bias included contamination, co-intervention, or lack of operational definition for some outcomes (e.g., wound healing) as illustrative examples.ConclusionsAside from mortality, there was limited evidence regarding outcomes of dysvascular PFA, particularly how outcomes differ between levels of PFA and TTA. Acknowledging that there is considerable uncertainty given the small body of literature on many topics where the risk of bias is high, the available evidence suggests that a large proportion of people with PFA experience delayed wound healing and ipsilateral reamputation. People with TTA have increased risk of mortality compared to those with PFA, which may reflect that those considered suitable candidates for TTA have more advanced systemic disease that also increases the risk of dying. Mobility and quality of life may be similar in people with PFA and TTA.Systematic review registrationCRD42015029186

<p>The number of Diabetic Foot Ulcer (DFU) cases is growing due to the rising number of older persons in society and the increasing worldwide prevalence of diabetes mellitus (DM). Indeed, a DFU occurs in approximately 1 out of every 7 patients with DM. Clinical preventive and management interventions for DFU typically include the employment of multiple guideline-based interventions, with the goal of preventing the onset of DFU in the first place. The development of new and effective interventions in wound care generally remains an area of intense research interest, especially in DFU, where the search continues for evidence on high efficacy, yet cost effective interventions. This clinically focussed paper will present an overview of DFU, introduce some of the costs associated with DFU prevention and management in addition to including important treatment considerations. This paper also highlights the urgent need for more high quality robust clinical trial research to meet the expanding treatment needs of this growing patient population</p>

The surgical decision for limb-salvage with free tissue transfer (FTT), partial foot amputation (PFA), or below-knee amputation (BKA) for complex lower extremity (LE) wounds hinges on several factors, including patient choice and baseline function. However, patient-reported outcome measures (PROMs) on LE function, pain, and QoL for chronic LE wound interventions are limited. Thus, the study aim was to compare PROMs in patients who underwent FTT, PFA, or BKA for chronic LE wounds. PROMs were collected via QR code for all adult chronic LE wound patients who presented to a tertiary wound center between June 2022 and June 2023. A cross-sectional analysis of patients who underwent FTT, PFA, or BKA was conducted. The 12-Item Short Survey (SF-12), PROM Information System Pain Intensity (PROMIS-3a), and Lower Extremity Functional Scale (LEFS) were completed at 1, 3, and 6 months and 1, 3, and 5 years postoperatively. Patient demographics, comorbidities, preoperative characteristics, and amputation details were collected. Of 200 survey sets, 71 (35.5%) underwent FTT, 51 (25.5%) underwent PFA, and 78 (39.0%) underwent BKA. Median postoperative time points of survey completion between FTT (6.2 months, IQR: 23.1), PFA (6.8 months, IQR: 15.5), and BKA (11.1 months, IQR: 21.3) patients were comparable (P = 0.8672). Most patients were male (n = 92, 76.0%) with an average age and body mass index (BMI) of 61.8 ± 12.6 years and 30.3 ± 7.0 kg/m2, respectively. Comorbidities for FTT, PFA, and BKA patients included diabetes mellitus (DM; 60.6% vs 84.2% vs 69.2%; P = 0.165), peripheral vascular disease (PVD; 48.5% vs 47.4% vs 42.3%; P = 0.790), and chronic kidney disease (CKD; 12.1% vs 42.1% vs 30.8%; P = 0.084). No significant differences were observed between FTT, PFA, and BKA patients in mean overall PROMIS-3a T-scores (49.6 ± 14.8 vs 54.2 ± 11.8 vs 49.6 ± 13.7; P = 0.098), LEFS scores (37.5 ± 18.0 vs 34.6 ± 18.3 vs 38.5 ± 19.4; P = 0.457), or SF-12 scores (29.6 ± 4.1 vs 29.5 ± 2.9 vs 29.0 ± 4.0; P = 0.298). Patients receiving FTT, PFA, or BKA for chronic LE wounds achieve comparable levels of LE function, pain, and QoL postoperatively. Patient-centered functionally based surgical management for chronic LE wounds using interdisciplinary care, preoperative medical optimization, and proper patient selection optimizes postoperative PROMs.

To evaluate the practice of off-loading diabetic foot ulcers (DFUs) using real-world data from a large wound registry to better identify and understand the gap between evidence and practice. Retrospective, deidentified data were extracted from the US Wound Registry based on patient/wound characteristics, procedures performed, and at which clinic the DFU was treated. 96 clinics (23 from the United States and Puerto Rico) : 11,784 patients; 25,114 DFUs : Healed/not healed, amputated, percent off-loading, percent use of total contact casting (TCC), infection rate : Off-loading was documented in only 2.2% of 221,192 visits from January 2, 2007, to January 6, 2013. The most common off-loading option was the postoperative shoe (36.8%) and TCC (16.0%). There were significantly more amputations within 1 year for non-TCC-treated DFUs compared with TCC-treated DFUs (5.2% vs 2.2%; P = .001). The proportion of healed wounds was slightly higher for TCC-treated DFUs versus non-TCC-treated DFUs (39.4% vs 37.2%). Infection rates were significantly higher for non-TCC-treated DFUs compared with TCC-treated DFUs (2.6 vs 1.6; P = 2.1 × 10). Only 59 clinics used TCC (61%); 57% of those clinics used traditional TCC, followed by TCC-EZ (36%). Among clinics using any type of TCC, 96.3% of the DFUs that did not receive TCC were "TCC-eligible" ulcers. Among clinics using "traditional" TCC systems, 1.4% of DFUs were treated with TCC, whereas clinics using TCC-EZ provided TCC to 6.2% of DFUs. Total contact casting is vastly underutilized in DFU wound care settings, suggesting that there is a gap in practice for adequate off-loading. New, easier-to-apply TCC kits, such as the TCC-EZ, may increase the frequency with which this ideal form of adequate off-loading is utilized.

To determine the outcome of diabetic neuropathic foot ulcers treated with Total Contact Cast (TCC) in terms of percentage of ulcers healed and time to heal. Analytical study. Department of Orthopaedic Surgery, Abbasi Shaheed Hospital, Karachi Medical and Dental College, from April 2005 to March 2007. The study included diabetic patients with non-ischemic neuropathic foot ulcers of upto grade 2 of Wagner's classification. Ulcers were debrided off necrotic tissues and Total Contact Cast (TCC) was applied. TCC was renewed every 2 weeks till healing. Cases were labeled as cast failure when there was no reduction in wound size in 4 consecutive weeks or worsening to a higher grade. Main outcome measures were the percentage of ulcers healed and time to heal in the cast. Thirty four (87.17%) patients were males and 5(12.82%) were females. The mean age was 62 +/- 13.05 years. All patients had NIDDM. Out of the 52 ulcers, 41(78.84%) healed with TCC in an average 2 casts duration (mean 32 days). There were 11(21.15%) cast failure. Majority (63.63%) of cast failure ulcers were located on pressure bearing area of heel. Most (90%) of the ulcers on forefoot and midsole region healed with TCC (p < 0.001). Longer ulcer duration (mean 57.45 +/- 29.64 days) significantly reduced ulcer healing (p < 0.001). Total contact cast was an effective treatment modality for neuropathic diabetic foot ulcers of Wagner's grade 2, located on forefoot and midsole region.

The purpose of this study was to compare the effectiveness of a removable cast walker (RCW) rendered irremovable (iTCC) with the total contact cast (TCC) in the treatment of diabetic neuropathic plantar foot ulcers. In a prospective, randomized, controlled trial, 41 consecutive diabetic patients with chronic, nonischemic, neuropathic plantar foot ulcers were randomly assigned to one of two groups: a RCW rendered irremovable by wrapping it with a single layer of fiberglass casting material (i.e., an iTCC) or a standard TCC. Primary outcome measures were the proportion of patients with ulcers that healed at </=12 weeks, healing rates, complication rates, cast placement/removal times, and costs. The proportions of patients with ulcers that healed within 12 weeks in the iTCC and TCC groups were 80 and 74%, respectively (94 and 93%, respectively, when patients who were lost to follow-up were excluded). Survival analysis (healing rates) was statistically equivalent in the two groups, as were complication rates, but with a trend toward benefit in the iTCC group. The iTCC took significantly less time to place and remove than the TCC with 39% and 36% reductions, respectively. There was also an overall lower cost associated with the use of the iTCC compared with the TCC. The iTCC may be equally efficacious, faster to place, easier to use, and less expensive than the TCC in the treatment of diabetic plantar neuropathic foot ulcers.

BackgroundThe management of chronic diabetic foot ulcers (DFU) poses a great challenge to the treating physician and surgeon. The aim of this study was to identify the risk factors, clinical presentation, and outcomes associated with chronic DFU>6 months’ duration.MethodsThis prospective study was performed in Jabir Abu Eliz Diabetic Centre (JADC), Khartoum, Sudan. A total of 108 patients who had DFU for >6 months were included. Recorded data included patient's demographics, DFU presentation, associated comorbidities, and outcomes. DFU description included size, depth, protective sensation, perfusion, and presence of infection. Comorbidities assessed included eye impairment, renal and heart disease. All patients received necessary local wound care with sharp debridement of any concomitant necrotic and infected tissues and off-loading with appropriate shoe gear and therapeutic devices.ResultsThe mean age of the studied patients was 56+SD 9 years with a male to female ratio of 3:3.3. The mean duration of DFU was 18±SD 17 months (ranging from 6 to 84 months). Ulcer healing was significantly associated with off-loading, mainly the use of total contact cast (TCC) (p=0.013). Non-healing ulcerations were significantly associated with longer duration of the chronic DFU>12 months (p=0.002), smoking (p=0.000), poor glycemic control as evidenced by an elevated HbA1c (>7%), large size (mean SD 8+4 cm), increased depth (p<0.001), presence of skin callus (p<0.000), impaired limb perfusion (p=0.001), impaired protective sensation as measured by 10 g monofilament (p=0.002), neuroischemia (p=0.002), and Charcot neuroarthropathy (p=0.017).DiscussionRisk factors associated with chronic DFU of>6 months’ duration included the presentation of an ulcer with increased size and depth, with associated skin callus and neuroischemia, in a diabetic patient with a history of smoking and increased HbA1c >7%. Off-loading mainly with the use of TCC is an effective method of managing long-standing DFU.

The custom-fabricated total contact cast is commonly used in the treatment of diabetic foot disorders. This resource-consuming treatment option has been associated with iatrogenic morbidity as well as the need for urgent cast removal and inspection of the underlying limb when potential problems arise. Over a 10-year period, 381 diabetic patients had 2265 total contact cast applications by certified orthopaedic technologists, in a university orthopaedic practice, under the supervision of university faculty. Patients were stratified by glycemic control based on hemoglobin A1c levels, and obesity based on body mass index (BMI). Complications were grouped as (1) development of a new ulcer or wound, (2) new or increasing odor or drainage, (3) wound infection, (4) gangrene, (5) newly identified osteomyelitis, and (6) pain or discomfort necessitating cast change or removal. At least 1 complication was observed in 159 of 381 patients. The odds of experiencing a cast-related event for patients with a BMI greater than 30 kg/m2 was 1.55 times greater than patients with a BMI less than 25 kg/m2. As compared to patients with good glycemic control, the odds of experiencing a cast-associated complication was 1.27 times greater in patients with moderate glycemic control and 1.48 times greater in patients with poor glycemic control. The total contact cast is commonly used in the treatment of diabetic foot morbidity. Treatment-associated morbidity may well be greater than previously appreciated. Complications are more likely in patients who have poor glycemic control and are morbidly obese. This information will hopefully stimulate interest in developing commercially available nonrigid alternatives that retain the attributes of the resource-consuming rigid device, with the potential advantage of avoiding the associated morbidity.Levels of Evidence: Level IV, retrospective chart review.

Category:DiabetesIntroduction/Purpose:Venous Thrombo-Embolism (VTE) is a recognized complication of lower limb immobilization. In the neuropathic patient total contact casting (TCC) is used in the management of acute charcot neuroathropathy and/or to off-load neuropathic ulcers. To our knowledge, there is currently no literature stating the prevalence of VTE in patients, despite the possibility of prolonged lower limb immobilization. There are also no recommendations regarding VTE prophylaxis in the setting of TCCs. We report a retrospective case series assessing the frequency of symptomatic VTE in the patients treated with TCCs. Given that diabetic foot disease manifests as one of many co-morbidities in this medically complex group of patients we hypothesize that the rate of occurrence of VTE should be higher than that of the general population.Methods:Patients undergoing TCC between 2006 and 2018 were identified using plaster room records. These patients subsequently had electronic clinical letters and radiological reports assessed for details around the TCC episode, past medical history and any VTE events.Results:There were 143 TCC episodes in 105 patients. Average age at cast application was 55 years. The mean time in a cast was 45 days (range from 5 days to 8 months). 3 out of 4 patients had neuropathy as a consequence of diabetes. One TCC related VTE (0.7% of casting episodes) was documented. This was a proximal DVT confirmed on USS 9 days following cast removal. Only 3 patients received VTE prophylaxis while in TCC.Conclusion:Despite these complex patients having a multitude of co-morbidities the frequency of VTE in the TCC setting remains similar to that of the general population. This may be due to the fact that TCCs permit weight bearing or that Charcot arthropathy leads to a high outflow state, potentially turning Virchow’s triad in the patient’s favour. This case series suggests that, while all patients should be individually VTE risk assessed as for any lower limb immobilization, chemical thromboprophylaxis is not routinely indicated in the context of TCCs.