Shear and extensional flow of polyacrylamide solutions

Abstract

As part of an EEC Science Stimulation programme on extensional viscosity two major conferences were organised on the subject. The second of these was devoted to the results obtained on a standard fluid, M 1. The data obtained in shear flow was remarkably consistent from laboratory to laboratory. Extensional flow results presented quite a different picture. Using a series of nonequilibrium techniques such as the spinline rheometer, opposing jet, falling drop and converging flow, extensional viscosity results were obtained which differed by as much as two to three orders of magnitude. Nevertheless, it was apparent that consistancy did exist between similar techniques. It is in the context of this information that the measurements described below have been made. The shear and extensional flow properties of partially ionised polyacrylamide in solution at concentrations ranging from 5 ppm were measured. The method of solution preparation was found to have a profound effect on the behaviour of the solutions in shear flow. The influence of salt concentration and pH was investigated and is discussed in the context of molecular shape in solution. Extensional flow measurements, using the spinline rheometer, show that the solutions are strongly strain thickening even at concentrations as low as 5 ppm. These results are considered in the light of polymer entanglement and association in the strong flow field.