Physical workload of flight attendants when pushing and pulling trolleys aboard aircraft

Abstract

The musculoskeletal loads from moving trolleys aboard aircraft were assessed by observation of trolley handling on planes and by physical workload analyses of pushing and pulling of trolleys in a laboratory set up. Trolley handling by a total of 15 female flight attendants was observed on 10 short- and medium-distance flights in different types of aircraft. About 25 selected flight attendants (22 females; 3 males) of five German airlines took part in the laboratory study, which comprised three-dimensional (3D) measurements of posture and hand forces during pushing and pulling of trolleys in a variety of configurations. From the on-flight observations performed, between 150 and 250 trolley movements can be projected for a work shift. The greatest physical workload is to be expected at the beginning of service: The trolleys are fully laden then, and the cabin floor can still be inclined up to 8°, as the aircraft is still climbing, particularly on short-distance flights. The laboratory investigation revealed that the musculoskeletal workload from pushing and pulling depends essentially on the trolley load and on the gradient of the cabin floor. In addition, the degree of stressing depends significantly on the trolley type, mode of handling and personal dexterity. The up/down force component perpendicular to the direction of motion often achieved considerable amplitudes-in some cases equal to or exceeding the force in the direction of movement. The posture analysis demonstrated that pulling forced the flight attendants to adopt ergonomically unfavourable postures such as pronounced flexion of the back, particularly among female subjects. The highest values for flexion of the back occurred while pulling the half-size trolley. The results demonstrate that female flight attendants are likely to overload themselves if they frequently have to move heavily laden trolleys unaided on an inclined cabin floor. Relevance to industry On short distance flights, flight attendants have been complaining increasingly of high physical workload from manoeuvring trolleys. On the basis of the presented data airline companies may improve the trolley handling skills of their flight attendances by practical trainings and may ergonomically optimize the general service procedures aboard aircrafts.