Operative slip systems and their critical resolved shear stresses in η-Fe2Al5 investigated by micropillar compression at room temperature

Abstract

The plastic deformation behavior of single crystals of orthorhombic η-Fe2Al5 has been investigated by micropillar compression at room temperature as a function of crystal orientation and specimen size. Plastic flow is observed even at room temperature by the operation of six slip systems; (001)<010>, (001)<110>, (001)<130>, {22‾3}<110>, {311}<1‾03> and {301}<1‾03>. The CRSS values for the six identified slip systems are very high all in the range of 1.1∼1.5 GPa and do not vary much with specimen size. In the middle of the stereographic projection, the (001)<010>, (001)<110>, (001)<130> and {22‾3}[110] slip systems operate according to the relative Schmid factors with the similar CRSS values in the range of 1.08∼1.23 GPa. In orientations close to [001], the {311}<1‾03> slip system as well as the {301}<1‾03> slip system operate with a much higher CRSS values around 1.5 GPa, producing wavy slip traces due to the occurrence of frequent cross-slip among these slip planes. In orientations close to the [100]-[110]-[010] symmetry line, on the other hand, premature failure occurs without the operation of any slip systems, although, the Schmidt factor-wise, the {311}<1‾03> and {301}<1‾03> slip systems could operate. The selection of slip systems, their CRSS values and the possible dislocation dissociation modes are discussed based on the overlapped atomic volume that occurs during shear along the slip direction on the slip plane, taking into account the partial occupancies of Al atoms in the linear atomic chain along the orthorhombic c-axis direction.