Kinetics and Mechanism of the Reaction of Methacrolein with Chlorine Atoms in 1−950 Torr of N2or N2/O2Diluent at 297 K

Abstract

The rate constant of the reaction of Cl atoms with methacrolein (k(1)) has been measured relative to that of Cl with propane (k(2)) or cyclohexane (k(6)) at ambient temperature and pressures varying from 1-950 Torr. The experiments were carried out by irradiation (350 nm) of Cl(2)/methacrolein/propane or cyclohexane mixtures in N(2) or N(2)/O(2) diluent at ambient temperature in a spherical (500 cm(3)) Pyrex reactor (GC/FID analyses) or a 140 L FTIR smog chamber. The measured relative rate constant ratios in the GC/FID experiments were k(1)/k(2) = 1.464 +/- 0.015(2sigma) in N(2) and k(1)/k(2) = 1.68 +/- 0.03(2sigma) in N(2)/O(2) diluent (O(2) > 20,000 ppm). No pressure dependence was observed over the range studied in N(2) (120-950 Torr) using the GC/FID. In the FTIR/smog chamber experiments values of k(1)/k(6) = 0.645 +/- 0.032, 0.626 +/- 0.037, 0.586 +/- 0.026, and 0.479 +/- 0.024 were measured in 700, 100, 10, and 1 Torr, respectively, of N(2) diluent. Using k(2) = (1.4 +/- 0.2) x 10(-10) and k(6) = (3.3 +/- 0.5) x 10(-10) high pressure limiting rate constants of k(1) = (2.05 +/- 0.3) x 10(-10) [GC/FID] and (2.13 +/- 0.34) x 10(-10) [FTIR] cm(3) molecule(-1) s(-1) were determined. In experiments using the GC/FID reactor with N(2) diluent the following products (molar yields) were observed: 2,3-dichloro-2-methylpropanal [(47.2 +/- 8)% excluding error in calibration]; methacryloyl chloride [(22.9 +/- 2)%]; and 2-chloromethylacrolein [(2.3 +/- 0.8)%]. Addition of 200 ppm O(2) (with Cl(2) = 5000 ppm) resulted in a sharp reduction of the 2,3-dichloro-2-methylpropanal yield (to approximately 2%) with an accompanying appearance of chloroacetone [yield = (55 +/- 7)% decreasing to (44 +/- 7)% in air diluent]. The methacryloyl chloride yield was 23% for [O(2)]/[Cl(2)] ratios from 0 to 0.2 but decreased to near zero as the O(2)/Cl(2) ratio was increased to approximately 400. The variation in methacryloyl chloride yield with the O(2)/Cl(2) ratio in the initial mixture allowed an approximate measurement of the rate constant for the reaction of the methacryloyl radical with O(2) relative to that with Cl(2) (k(O(2))/k(Cl(2)) = 0.066 +/- 0.02). In experiments using the FTIR reactor in 700 Torr of N(2) diluent, methacryloyl chloride [(26 +/- 3)%] and HCl [(27 +/- 3)%] were observed as products. In 700 Torr of air diluent, the observed products were: chloroacetone [(44 +/- 5)%], CO(2) [(27 +/- 3)%], HCl [(21 +/- 3)%], and HCHO [(14 +/- 2)%], and CH(3)C(O)CH(2)OH (3-4%). The observation of CH(3)C(O)CH(2)OH indicates the presence of OH radicals in the system. At atmospheric pressure and 297 K, the title reaction proceeds [(24.5 +/- 5)%] via abstraction of the aldehydic hydrogen atom, [(2.3 +/- 0.8)%] via abstraction from the -CH(3) group, and approximately [(47 +/- 8) %] via addition to the CH(2)=C < double bond with most of the addition occurring at the terminal carbon atom (uncertainties represent statistical 2sigma). The results are discussed with respect to the literature data.