Agitator speed and dissolved oxygen effects in Xanthan fermentations

Abstract

Agitation speed affects both the extent of motion in Xanthan fermentation broths because of their rheological complexity and the rate of oxygen transfer. The combination of these two effects causes the dissolved oxygen concentration and its spatial uniformity also to change with agitator speed. Separating these complex interactions has been achieved in this study in the following way. First, the influence of agitation speeds of 500 and 1000 rpm has been investigated at a constant nonlimiting dissolved oxygen concentration of 20% of air saturation using gas blending. Under these controlled dissolved oxygen conditions, the results demonstrate that the biological performance of the culture was independent of agitation speed as long as broth homogeneity could be ensured. With the development of increasing rheological complexity lending to stagnant regions at Xanthan concentrations >20 g/L, it is shown that the superior bulk mixing achieved at 1000 rpm, compared with 500 rpm, leading to an increased proportion of the cells in the fermentor to be metabolically active and hence higher microbial oxygen uptake rates, was responsible for the enhanced performance. Second, the effects of varying dissolved oxygen are compared with a control in each case with an agitator speed of 1000 rpm to ensure full motion, but with a fixed, nonlimiting dissolved oxygen of 20% air saturation. The specific oxygen uptake rate of the culture in the exponential phase, determined using steady-state gas analysis data, was found to be independent of dissolved oxygen above 6% air saturation, whereas the specific growth rate of the culture was not influenced by dissolved oxygen, even at levels as low as 3%, although a decrease in Xanthan production rate could be measured. In the production phase, the critical oxygen level was determined to be 6% to 10%, so that, below this value, both specific Xanthan production rate as well as specific oxygen uptake rate decreased significantly. In addition, it is shown that the dynamic method of oxygen uptake determination is unsuitable even for moderately viscous Xanthan broths. © 1998 John Wiley & Sons, Inc. Biotechnol. Bioeng. 57: 198–210, 1998.